Inleiding

This guide will help you replace the outer LCD screen if broken or in need of repair.

Make sure you remove the battery by lifting the tab on the back of the phone before opening the case.
  • Make sure you remove the battery by lifting the tab on the back of the phone before opening the case.

  • Flip open the phone and locate the four screw covers.

Voeg opmerking toe

Remove all four screw covers by using an IPod opening tool. They should come off relatively easy.
  • Remove all four screw covers by using an IPod opening tool. They should come off relatively easy.

Voeg opmerking toe

Using a T6 Torx screwdriver, remove all four screws.
  • Using a T6 Torx screwdriver, remove all four screws.

Voeg opmerking toe

Once the screws are removed, use an IPod opening tool to separate the front cover from the inner screen cover. Run the Ipod opening tool down both sides,disconnecting the tabs that hold the covers together. Run the Ipod opening tool down both sides,disconnecting the tabs that hold the covers together.
  • Once the screws are removed, use an IPod opening tool to separate the front cover from the inner screen cover.

  • Run the Ipod opening tool down both sides,disconnecting the tabs that hold the covers together.

Voeg opmerking toe

Pull the inner screen cover towards you and up in order to separate it from the front cover. Pull the inner screen cover towards you and up in order to separate it from the front cover.
  • Pull the inner screen cover towards you and up in order to separate it from the front cover.

Voeg opmerking toe

Remove the tape from the bottom of the LCD screen.
  • Remove the tape from the bottom of the LCD screen.

Voeg opmerking toe

Carefully lift the LCD screen and peel it from the gold ribbon. The sticky connection runs all the way around the LCD screen. Carefully lift the LCD screen and peel it from the gold ribbon. The sticky connection runs all the way around the LCD screen. Carefully lift the LCD screen and peel it from the gold ribbon. The sticky connection runs all the way around the LCD screen.
  • Carefully lift the LCD screen and peel it from the gold ribbon. The sticky connection runs all the way around the LCD screen.

Voeg opmerking toe

Flip the screen over so that you can see the outer LCD screen and the circuit board. Insert spudger in the bottom right corner. Lift up and move the spudger across the bottom.
  • Flip the screen over so that you can see the outer LCD screen and the circuit board.

  • Insert spudger in the bottom right corner.

  • Lift up and move the spudger across the bottom.

  • The third photo is rotated 180 degrees.

Voeg opmerking toe

Use the pointy side of the spudger to peel off the interior tape. Flip the assembly over and peel the circuit board from the screen.
  • Use the pointy side of the spudger to peel off the interior tape.

  • Flip the assembly over and peel the circuit board from the screen.

Voeg opmerking toe

Use the spudger to remove the LCD screen from its backing. Use the spudger to remove the LCD screen from its backing.
  • Use the spudger to remove the LCD screen from its backing.

Voeg opmerking toe

The outer LCD screen can be found on the circuit board, which is attached to the back of the inner LCD screen.
  • The outer LCD screen can be found on the circuit board, which is attached to the back of the inner LCD screen.

Voeg opmerking toe

Use an IPod opening tool to carefully lift the screen from its backing. Use your finger to pull the screen forward.
  • Use an IPod opening tool to carefully lift the screen from its backing.

  • Use your finger to pull the screen forward.

Voeg opmerking toe

Pull the screen and the tape ribbon off the circuit board. Pull the screen and the tape ribbon off the circuit board.
  • Pull the screen and the tape ribbon off the circuit board.

Voeg opmerking toe

Conclusie

To reassemble your device, follow these instructions in reverse order.

Joshua Herrmann

Lid sinds: 16-04-10

8 Reputatie

16 handleidingen geschreven

Team

Cal Poly, Team 6-14, Maness Spring 2010 Lid van Cal Poly, Team 6-14, Maness Spring 2010

CPSU-MANESS-S10S6G14

4 Leden

16 handleidingen geschreven

Voeg opmerking toe

Weergavestatistieken:

Afgelopen 24 Uren: 0

Afgelopen 7 Dagen: 0

Afgelopen 30 Dagen: 0

Altijd: 829